乙酰化处理对樟子松木材耐光性和热稳定性的影响

【目的】探讨乙酰化处理对人工林木材耐光性和热稳定性的影响,为木材颜色调控技术及高耐光染色木材的研发提供理论依据。【方法】以樟子松木粉为试样,加入乙酸酐和二甲苯溶液,在120℃条件下分别反应5,10,20,40,60 min,测试乙酰化处理时间对木粉增重率的影响;分别称取1 g经不同时间乙酰化处理的木粉和未处理木粉,置于 UV老化试验箱内辐射100 h,利用红外光谱分析 UV辐射前后乙酰化木粉化学官能团的变化,通过热重和扫描电镜分析乙酰化木粉的热稳定性及其形貌变化。【结果】随着乙酰化处理时间的延长,樟子松木粉的增重率呈现先增加后降低的趋势,在处理40 min 时木粉增重率最大;乙酰化木粉在1741 cm －1和1385 cm －1处的CO,C—H特征吸收峰强度均大于原木粉,处理时间40 min 时木粉的吸收峰强度最大;UV 辐射后,乙酰化木粉在1508 cm －1处木质素苯环特征吸收峰强度明显大于原木粉,处理时间40 min 时木粉的吸收峰强度最大,表明木粉经乙酰化处理后光稳定性得到提升;热重分析显示,经乙酰化处理后,木粉热分解所需的温度明显提高,表明乙酰化木粉的热稳定性好于原木粉;扫描电镜分析表明,乙酰化处理可增强木粉微观构造抵抗光劣化的能力。【结论】乙酰化处理能有效抑制樟子松木材的光降解反应并提升其热稳定性。     

A microwave tomographic system for wood characterization in the forest products industry

Abstract

Nondestructive testing and evaluation techniques able to extract information about the internal structure of the samples under test are very important in the wood industry. Microwave imaging systems have been considered for a long time promising apparatuses for this task. In this framework, approaches exploiting the full scattering phenomena for creating images of the distributions of the dielectric properties of the targets have been developed in the last few years. In this paper, a prototype of microwave tomographic system is presented and several experimental validation confirming its suitability for the use in the wood and forest product industry are reported.     

Changes in soil macropores: Superposition of the roles of organic nutrient amendments and the greenhouse pattern in vegetable plantations

Organic farming can potentially mitigate soil compaction, which commonly occurs in vegetable plantations, particularly in greenhouses when compared with open‐air systems. Although several studies have addressed the effect of planting patterns on soil pore characteristics, few studies have focused on changes in pore attributes under organic fertilization. We used adjacent fields during green manure planting as a control to compare the differences in soil physicochemical and macropore parameters between 14‐year‐old greenhouse plots and open‐air plots under organic fertilization. Pearson's correlation analysis was performed to analyse the drivers of soil macropore characteristics in vegetable plantations in Jiangsu Province, China. A significant increase in connectivity, fractal dimensions and total macroporosity and a decrease in bulk density after 14 years of organic farming, particularly in the surface layer in the greenhouse, were observed. However, the difference in pores in the plough pan layer was not significant between the treatments. The volume of small pores (50–500 μm) and medium pores (500–1,000 μm) increased significantly (p < 0.05) in both the greenhouse and open‐air systems, showing significantly positive relationships with soil organic matter (SOM) and total nitrogen (TN) content. Large pores (>1,000 μm) showed a clear decrease, especially in open‐air fields, possibly due to the disappearance of the original straw residues in the surface layer. Small and medium pores in the plough layer increased in greenhouse fields, whereas the opposite occurred in open‐air fields. Overall, compared with open‐air systems, long‐term organic greenhouse patterns had a significantly positive effect on soil pore attributes.     

不同氮素水平下双季稻株型与冠层内光截获特征研究

本文旨在阐明双季稻株型与冠层内光合有效辐射截获的时空分布特征。选用4个不同株型早、晚稻品种,设置4个不同施氮水平,系统观测其植株形态和冠层内光合有效辐射截获率(IPAR)的时空分布状况。结果表明,施氮水平对早、晚稻株高、穗长、叶长和叶基角均有显著影响,均表现为随施氮水平的增加而增大;早、晚稻孕穗期的分层叶面积指数(LAI)和向上累积LAI大于抽穗后12 d,分层LAI呈冠层中部大于上部和下部的分布特征,最大分层LAI出现在0.58相对高度处;冠层上中部分层LAI和向上累积LAI随施氮水平的增加而增大;向上累积LAI随相对高度呈S型曲线分布,可用Logistic方程定量描述(R~2 0.99);早、晚稻孕穗期的冠层IPAR大于抽穗后12 d,且随施氮水平的增加而增大,其日变化表现为正午较小,早晚较大;株型紧凑的早、晚稻品种,冠层IPAR低;冠层IPAR与向下累积LAI之间的关系可用方程IPAR=a (1-e~(-b×LAI))定量描述(R~2 0.88);冠层内IPAR的三维空间分布表现为冠层上中部水平面上IPAR较低,光斑变化大,冠层下部水平面上IPAR较高,光斑变化较平缓,同一冠层高度水平面上的IPAR呈不均匀分布。研究结果可为双季稻高产栽培及理想株型的优化设计提供支撑。     

一种播补一体化新型马铃薯播种机的设计与试验

现有马铃薯漏播补偿方案普遍需附加补偿种箱及单独设置补偿排种通道，导致系统结构复杂、补偿种薯落点偏差较大。为此，本研究提出了基于单向离合器的播补一体化马铃薯播种机新方案。该方案排种链轮正常播种使用地轮动力，而补偿状态在单向离合器协调下转移至补偿专用电动机，补偿完成后则继续恢复至地轮。基于此，在计算所需时间内，采用后一取种勺上的种薯直接追赶前一缺种位置的追赶式补偿方案，可以使补偿种薯也在原排种通道中运动，独立的补偿种薯专用通道不再需要，从而使系统结构简化、可靠性提高。样机田间试验表明，所采用的红外辐射排种监测系统误判率不超过1‰，系统平均自然漏播率对排种速度不敏感，漏播补偿成功率随着排种链速度的增加而快速降低，但即使达到正常排种链速最高值0.8 m·s^-1，依然有平均74%以上的漏播能被成功补偿，系统平均最终漏播率不足平均自然漏播率的1/4，漏播补偿作用效果明显。     

基于土壤微波辐射布儒斯特角反演土壤含水率

在利用被动微波遥感技术进行裸露地表土壤含水率(Soil Moisture Content,SMC)的反演中,土壤粗糙度是制约反演精度的最关键因素。该研究利用改进的积分方程模型(Advanced Integral Equation Model,AIEM)进行地表多角度微波发射率的模拟,探索地表微波辐射多角度信息用于提高地表SMC反演精度的可行性。基于不同SMC和不同粗糙度地表多角度V极化发射率数据的变化趋势提取土壤介质布儒斯特角,结果表明,土壤布儒斯特角对SMC具有较高的敏感性,C波段(6.6 GHz)不同含水率土壤的布儒斯特角分布在60°～80°范围内。基于AIEM模拟数据的分析发现,土壤布儒斯特角正切值与SMC具有较好的线性关系,线性拟合决定系数为0.94,均方根误差为0.027cm~3/cm~3,并得到了基于布儒斯特角的裸露地表SMC反演算法。基于模拟数据的算法验证结果表明,算法的SMC预测值与理论值的决定系数为0.95,均方根误差为0.024 cm~3/cm~3。算法在不同土壤粗糙度自相关函数下均表现出稳健的特性,SMC预测精度最大均方根误差为0.027 cm~3/cm~3,最小为0.023cm~3/cm~3。基于布儒斯特角的SMC反演算法利用的是多角度土壤发射率的相对变化而非其绝对数值,该研究为SMC的多角度被动微波遥感提供了一种不同的研究思路。     

微波辐射法竹浆纤维素的中性TEMPO氧化及表征

采用微波辐射法和中性2,2,6,6-四甲基哌啶-1-氧化物(TEMPO)自由基氧化工艺来预处理竹浆纤维素,之后用超声波机械处理制备微纤化纤维素。实验结果表明,在60℃下,TEMPO用量为0.15 mmol/g(以绝干浆计,下同),Na Cl O2用量为10 mmol/g,Na Cl O用量为1 mmol/g,微波氧化2 h,其羧基含量最高到达0.729 mmol/g,氧化效果最佳,超声波处理后微纤化纤维素得率高达85.7%。FT-IR分析表明纤维素氧化后引入羧基官能团;XRD结果揭示纤维素氧化反应只发生在纤维素的无定型区或结晶区表面;纤维素氧化前后的聚合度(Dp)结果表明相对于碱性氧化,微波辐射和中性TEMPO氧化对纤维的降解程度低,从而有效地保持了纤维素原本的长度。     

中药合理辐照灭菌剂量设定的初步研究

目前尚无适用于中药辐照合理剂量设定的标准,为了规范中药辐照剂量的设定,本试验参考ISO 11137的标准抗性分布(SDR),计算中药辐照的理论剂量,并与9种中药粉和1种丸剂的实际系列辐照剂量进行比对。结果表明,丸剂和个别中药粉理论剂量比实际剂量偏小,达到-88%~-50%;有7种中药粉的理论剂量与实际剂量基本一致,偏差约为1k Gy。推断大部分中药粉可以通过SDR计算出合理的理论剂量,但对丸剂不建议按照SDR直接进行辐照剂量设定。本研究结果有效地提高了中药合理剂量筛选的效率,降低辐照风险,为中药辐照灭菌剂量的合理设定提供了方法参考。     

In UV‐B Irradiated Rice High Levels of Mn Limits Chloroplasts Injury Triggered by Oxidative Stress

The molecular mechanism to control the oxidative burst exerted by Mn accumulation in rice (Oryza sativa L.) plants, grown in hydroponics containing 0.5, 2 and 8 mg l^–1 Mn and irradiated with a total biological effective UV‐B irradiation of 20.825 kJ m^?2, was investigated in the chloroplasts at the 15th and 21st days after germination. In both experimental periods, Mn accumulation kinetics in the leaves and in the chloroplast lamellae displayed overall increases. Coupled to higher membrane selectivity, superoxide production and acyl lipids peroxidation in the thylakoids decreased, prompting upper rates of the Hill and Mehler reactions. Connected to UV‐B irradiation, higher accumulated Mn in thylakoids was found to be chelated in a 36.5 kDa protein, with Mn/protein ratio of about 1 and high content of Gln, Asp, Glu, Leu and Gly, being its EPR spectrum characteristic of high‐spin Mn(II), in a S = 5/2 ground state. As this protein exhibited enzymatic catalysis of superoxide dismutation, it was concluded that, under UV‐B irradiation, the high internal tolerance of Oryza sativa L. to Mn during the vegetative growth also triggers the synthesis of a manganese protein that mimics superoxide dismutase functioning, therefore furnishing an additional intimate protection against oxidative stress.